Heated Water Holding Tank
Once you have your boiler you need a holding tank. Your holding tank needs to be strong enough to handle the pressure of the hot water and well insulated to keep your warmed water warm for as long a possible.
The Mega-Stor is a stainless-steel indirect water heater which stores abundant domestic hot water utilizing energy provided by your boiler. With a stainless steel, smooth surface coil that transfers heat throughout the tank, the Mega-Stor is capable of recovery rates well in excess of a typical gas, electric or oil water heater. The two inch thick layer of polystyrene foam insulation keeps the water in your Mega-Stor hot for hours during stand-by periods. The Mega-Stor is also equipped with a removable cover for ease of inspection. Mega-Stor has a limited lifetime warranty. Capacity is 40 gallons.
Crown has several sizes of water holding tanks from 20 to 119 gallons but theyre pricey. Click on image to see details.
Outside Wood Burning Water Heater
The outdoor wood-burning water heater is actually a wood-burning furnace situated outside, at a safe distance, and it provides hot water through the pipes buried in the ground.
Wood-fired hot tub water heater
If looking for a wood-fired hot tub water heater, check out Chofu, a Japanese hot bath equipment company. The Chofu heater is made of high-quality stainless steel, and it can rise 247 gallons of 47 F hot water in about 3 hr and run it without using the electricity, but thermo-siphon principle. You can even retrofit an existing hot tub.
It is inexpensive to operate this type of a wood-burning water heater, as the cost is only wood. It is ideal for use in the cottage, even homes for heating hot tubs and pools.
Wood burning is not a practical way to heat the water, especially during the summer months. You just don’t want to fire the unit up every time you want some hot water. But if you cannot avoid it, use it in combination with solar heating. Be sure that the tank size is large enough to absorb the heat between the usage cycles and prevent overheating. Also, this type of water heating is not for the older and disabled as it requires much physical input. There is also a lot of planning involved, and it requires ordering and sawing logs and storing them.
No Electricity Needed But How
You only need two things to work your wood fired hot tub: water and wood. As the water is heated in the coil it begins to rise . The water follows the spiral of the coil up and back out into the tub. Cold water from the bottom of the tub is sucked into the bottom inlet of the coil which starts a steady flow without a pump. This scientific phenomenon is called thermosyphon.
You May Like: Warrior Lodge Fort Leonard Wood
How Much Does An Oil Hot Water Heater Cost
The cost of an oil hot water heater varies greatly depending on several factors, including size, features, size, and technology. Oil-fired water heaters tend to be one of the more expensive options due to the numerous advantages. A common estimated price range for those featured in this article is $1,000 to $3,000.
Wood Burning Water Heaters How It Works Types Tips

Wood burning water heaters and wood-fired furnaces are heating appliances that use wood as the energy source for home heating and domestic hot water preparation. They are not as popular as they used to be, mainly because of today’s modern life, urban living, and the availability of gas and electricity in almost any home.
The wood-fired appliances for DHW preparation will be reviewed here because they are pioneers in the water heating industry. We will also provide some useful tips if you are interested in buying or making one.
Also, due to the rising cost of other energy sources, including gas and electricity, you might decide that this is the most affordable if not the only way for your home or cottage. They are ideal for heating hot tubs, above-ground pools, and storage tanks.
We will cover different types, from the simple wood stove hot water preparation in the large pot to the outdoor wood-fired furnaces.
Recommended Reading: Wood Range Hood Cover Plans
What Wood Should I Use For My Slow Combustion Heater
The most important thing to be mindful of when choosing wood to run in your slow custombustion heater or stove is that the wood is properly seasoned i.e. dried. A good seasoned wood will have been dried over 2-5 years depending on the density.
If you put wet woodinto your firebox all the energy produced goes into drying out the wood not producing heat.
The best Australian hardwood sourced from a professional wood dealer should be dry before sale.
If you are sourcing your own wood you should be looking to cut dead limbs or fallen trees.
If your wood is not properly dired it will not only effect your heat output and energy usage but also effect the heat temperture reached and smoke output.
Tip: If the bark is still attached or can’t be removed easily from the log or branch then it is too green to burn.
What Is Hydronic Heating
Hydronic Heating is a cost-effective form of in-home heating that combines smart energy with innovative technology to produce the most efficient heating system on the market.
The systems use water to move heat from a source such as a gas boiler or heat pump through piping to each individual room.
Its often installed in concrete slabs, radiator panels and/or heated towel rails.
Don’t Miss: Wood Fired Pizza Wedding Catering
Hot Water System Two From Lehemans
This sturdy wood fired water heater is made entirely of strong, 3/16 thick welded steel. It hold 15 gallons of water.
Water completely surrounds 2.4 cu ft firebox, so all the heat goes toward heating the contents.
The dimensions are: 24Hx20Wx34L, 235 lbs. and can burn up to 26 logs. It requires a 6 flue. There is a draft control on the door.
The Wood-Fired Water Heater is exempt from EPA regulations and is legal for sale in most of the USA. However, it is not legal for sale in the state of Washington.
If you are already using a wood stove for heating and cooking heres an option that combines those with water heating too:
This Elmira, Fireview wood stove has an optional built-in water jacket so you can heat your house, cook your food, and heat your water all at the same time.
Its a well thought out product.
The Elmira Fireview cookstove brings the old-world coziness of the fire and the modern convenience of gas cooking into your kitchen. Choose the features that suit your needs: enjoy the incomparable warmth and pleasure of wood cooking make meals faster and keep your kitchen cooler on hot summer days with optional high-output gas burners or, extend your prep area with the optional work surface. A large viewing window lets you enjoy the dramatic display of the fire while quickly and easily fine-tuning the flame for perfect cooking temperatures every time.
Connecting To Your Hot Water System
The Axeman Fire Flue hot water heater connects directly to your homes existing hot water system. Run a pipe from a T off of your cold water line, to the bottom inlet on the Axeman. Then run a pipe from the top outlet to a T at the outlet of your existing hot water heater tank. All connections can be made with common fittings from your local hardware store.
You May Like: Courtyard By Marriott Pittsburgh North Cranberry Woods
Our #1 Rated Pick: Bradford White Sw
The Bradford White SW-2-120-L is an indirect fired hot water heater that works by attaching to your home or buildings boiler.
The heat in the boiler is what heats the water as opposed to the water heater itself. It works with gas, oil, and electric boilers.
The Hydrojet® Total Performance System and Vitraglas® keep the tank clean without any additional effort on your part. First-hour delivery is 325 gallons, and the tank holds 116 gallons.
Liter Stainless Steel Hot Water Boiler
Approx. Rs 40,000 / Piece
- Country of Origin: Made in India
- Wood Consumption: 4 kg/hr
80 Liter Stainless Steel Hot Water BoilerOther Details
- Modern storage water heater.
- Works with waste fire wood.
- With 3 kgs. of waste fire wood it will give hot water for 10 persons. The cost per person is about 45 paise
- Within 20-25 minutes, the hot water ready.
- Hot water connection can be given to upper floors.
- The system is very safe, fitted with safety valve.
- Is suitable for hard water also.
- This type of heaters are generally suitable for Hotels. Now we have made it possible for small houses.
- Fitted with temperature gauge.
- Special coating applied to prevent rust formation. It will work 5 to 7 years, if maintained properly.
- Retains heat upto 6 hours in plains and 3 hours in hill stations.
- With this water heater, the cost of bath per person per day is 45 paise. The same with electric water heater is Rs.2.15.
- Construction : The heaters are made with thick gauge SS and withstand the pressure. It is suitable for hard water also. It is rust proof.
- Fuel: It works with Firewood, Charcoal, Domestic and Agricultural waste.
Capacity In Liter | Lead Time to Reach 60 Deg C In minutes | Hot Water Output Per Minutes at 60 Deg C in Liter | No. of Person at the Rate of 20 Liter |
80 |
Don’t Miss: Wood Floor With Tile Inlay
Notes On Installing The Axeman
- Installation in as little as a hour.
- For both high and low pressure systems.
- Three quarter inch fittings for both inlet and outlets. Suitable for copper tubing to be plumbed directly to your existing hot water tank.
- Uses compression fittings no welding or soldering necessary.
- Make sure the outlet on your existing water heater is higher than the water outlet on the top of the Axeman without downward loops that could create air locks.
- If your hot water tank is lower than the Axeman, a pump will be needed.
- If you are in doubt, seek the assistance of a plumber or handyman.
- Insulating all pipes will help prevent heat loss. Pipe insulation can be purchased or made from other materials such as carpet or underlay.
- When your electric water heating is not needed it can be turned off at the power source.
- Longer distances from your hot water storage tank will increase heat loss and efficiency.
- Comes in standard 6 flue diameter and can be custom ordered for fitting or artistic design at an additional cost.
- Made in Australia to high standards.
- Heavy duty construction is designed to handle up to 300 lbs. .
- Only one of its kind being manufactured.
- Shipping is free anywhere in Australia. Shipping available outside Australia at additional cost.
To order your Axeman Fire Flue, call today on 6295 0987 andreceive free shipping to anywhere in Australia.All queries to the number above, or
What Are The Advantages And Disadvantages Of An Oil Fired Water Heater

Why would someone choose an oil water heater as opposed to an electric or gas water heater? Well, it turns out there are plenty of reasons. Here are some of the advantages and disadvantages of oil water heaters to help you reassure your decision..
Advantages:
- Heats water 4x more quickly
- Extra insulation
Recommended Reading: Quadra Fire Expedition Ii Wood Insert
Wood Fired Water Heater
A wood fired water heater can be good for off grid applications. We have one in a remote cabin and it produces all the free hot water we want to use. Its similar in shape and size to a small gas water heater but has a small wood firebox at the bottom.
This type of water heater can be plumbed into your homes hot water line, just the same and just as easy as any traditional gas or electric water heater. We actually have both a propane and the wood fired water heater hooked up parallel next to each other. A valve between the two allows us to simply direct which one the water will flow through.
The only problem with the wood fired water heater is there is some inconvenience. In order to have hot water we have to plan ahead and build a fire ahead of time.
The firebox is small and the door is even smaller so it can only handle small pieces. It does draft very well and is easy to get a fire started. We mostly use small flakes and wood chips that accumulate around our wood splitters for fuel. Just a few of these is all it takes to heat the whole tank of water.
It can take up to 20 minutes to a half hour for the water to get over 120 degrees. At that point there is enough hot water for two hot showers. And I dont mean just quick showers, there is actually enough to enjoy a good shower, plus enough left over to wash the dishes.
What Are Oil Hot Water Heaters
Like all water heaters, they provide heat to your homes water when you want to wash clothes in hot water or take a warm bath or shower. An oil hot water heater, also known as an oil fired water heater or oil boiler, uses oil to generate heat instead of electricity or gas.
Oil water heaters are the least common water heater for residential homes but one of the most common options for commercial buildings. However, larger households also consider these rare models as well. Like most water heaters, oil water heaters usually utilize a tank system that stores standing water as it is heated.
Recommended Reading: Camp Of The Woods Camp Cam
Wood Fired Pool Heaters
Wood Fired hot tub & pool heaters are an ideal way to extend the swimming season and save $$$ on operating costs. These heaters are specifically designed for hot tubs and smaller pools or lap pools. These heaters use a unique physical principle called Thermosiphon. Thermosiphon is the principle that hot water rises. It is used in many heating applications and is ideal in low flow requirements such as pool or hot tub heating.
Ofuro Tub With Wood Fired Heater
Our wood fired hot tub heater systems are a very economical way to enjoy your Northern Lights Cedar Tub. The only additional cost would be the preparation of a solid foundation. The wood fired tub system is very inexpensive to operate . It is ideal in cottage country, where typically users enjoy the pleasures of a soak during weekends and holidays. Wood fired heating systems release considerable amounts of heat. Lake water can be heated to operating temperatures in as little as 1-4 hours depending on the starting temperature and size of tub. The draw back of the Chofu system is that it must be drained and filled more often unless a optional 120VAC filter/pump system is added.
All tub kits come complete with materials and hardware.
The TimberLine Wood Water Stoves are precision built wood burning water heaters designed specifically for hot tubs and above ground pools. They circulates water using the principal of thermosiphon , eliminating the need for a circulating pump or electricity. This unique feature opens up a whole new range of possibilities for alternative hot tubs. Now you can have a basic soaking tub without pumps, chemicals, or high maintenance.
Read Also: Can You Put Solo Stove On Wood Deck
Wood Fired Heater And Forced Circulation Filter
The TimberLIne Wood Water Stoves have many advantages over Submersible in tub versions:
- No interior room is lost compared to submersibles which take up the room of 2 people.
- Is not effected by a minimum water volume level that an aluminum heater requires.
- Allows for a marine grade vinyl insulating cover to be used thus retaining heat much better over a weekend .
- Water stays cleaner, as wood is not being loaded inside the tub.
- Better temperature control, using a high and low speed draft control to regulate the heating rate.
- Vented smoke-outlet for secondary combustion provides less smoke and sparks. Automatically circulates the water using thermosiphon .
How Long Do Oil Hot Water Heaters Last
Water heaters with a tank system in general last at least ten years, and oil hot water heaters last a couple of years longer. Of course, the life expectancy depends on several variables, including:
- Professional installation
- Quality of water heater
Picking the right product will have a large impact on the life expectancy of the oil water heater. We highly suggest you hire a professional plumber to install the water heater to avoid problems that may occur from incorrect installation. While oil water heaters dont require extensive maintenance, you must perform a little maintenance required to keep the unit working effectively.
Don’t Miss: Solid Wood King Bed Frame With Headboard
Quick And Easy Installation
Installing the Coil Kit to your tub takes about 20 minutes and the only tool you need is a power drill. Simply drill two holes in the side of your tub, screw in our universal through wall ports and connect the coil using the easy to connect fittings. The video below shows a quick overview of the installation process.
Commercial Wood Fired Water Heater

- Minimum Order Quantity 1 Piece
- Size 500 Lit
- Capacity 40 litres to 1000 litres
- Material MS
- Capacity 40 litres to 1000 litres
- Material Available SS,MS
- Suitable For Homes,Lodges Hotels Hostels Industries Canteens Poultries Pools Places where hot water is used.
- Firelit water heaters cut off your electricity bill and work with very less quantity of industrial and agricultural wastes.
- Firelit is a storage type water heater and it provides a wide range of capacities starting from 40 liters to 1000 liters.
- Firelit gives a 2 year warranty for domestic and non-domestic units and the unit has durability up to 15 years.
- Firelit Water can be supplied to the upper floors.
- It requires only less space for installing .
- The furnace is constructed to hold enough fuel and it is designed in such a way that the water gets heated in very less time. Hence it consumes less fuel and supplies hot water in no time.
- The storage area is coated with a corrosion resistant, a high-temperature coating that prevents the unit from giving rusty water hence gives sturdy and hygienic water.
- Type of Collector Evacuated Tube Collector
- Frame Angle 27 Degree
- Size 47 x 1800 mm
- Volume of tank 100 to 300L
- Number of Persons to Use 3 to 10
- Number of Tubes 12, 15, 18, 24, 28, 35
- Insulation Material High Quality PU Material
- Outer Tank Powder Coated
Recommended Reading: Woods Edge Apartments Asheville Nc